新聞中心

聯系我們

湖北襄陽忠東機電設備有限公司

24小時銷售熱線:

手機:15871070288 彭經理

Q Q:61102568

手機:13597504406 秦經理

Q Q: 2448782675

辦公室熱線:

電話:0710-2350995

傳真:0710-3816559

郵箱:[email protected][email protected]

網址:www.469893.tw

地址:中國湖北襄陽市樊城區柿鋪正英工業園

繞線式水阻啟動柜工作原理?球磨機用水阻柜起動效果好不好?水阻柜能頻繁起動多少次?

繞線式水阻啟動柜概述

I. Overview

ZDR系列液體電阻起動器是為了進一步改善大、中型繞線式異步電動機的起動性能而研制成功的新一代起動控制裝置,通過在被控電動機的轉子回路中串入液體電阻,隨電動機起動時自動投入并在預定的時間內自動、無級、連續切除,克服了頻敏變阻器、油浸變阻器、鑄鐵變阻器等老式起動控制設備沖擊電流大(一般約為額定電流的3~5倍),起動不理想等不足,使電機在理想的起動電流條件下平穩起動,均勻升速,對保護電機、用電設備、電網及節能等方面有顯著效果。該設備在起動、停止、故障保護、聯絡、報警、顯示等方面、精心設計,與其它老式起動器相比較,具有自動化程度高、起動電流?。ㄒ话阈∮陬~定電流的1.3倍)、電氣及機械沖擊小、特別適宜于重載起動等特點,電網電壓低亦能順利起動,降低了變壓器的容量,是目前球磨機、提升機、破碎機、壓縮機、風機、水泵等重負載的最理想的起動控制設備。

ZDR series liquid resistance starter is a new generation starting controller researched and developed to further improve starting performance of medium and large coil-winding asynchronous motor. By connecting a liquid resistance in rotor loop of motor controlled, which automatically runs upon starting of the motor, and disconnects automatically, steplessly and continuously as scheduled, the following deficiency was overcome: impulse current of obsolete starting controllers such as frequency sensitive rheostat, oil immersing rheostat and cast iron rheostat is strong, and starting process is not desirable. In this case, motor starts under ideal starting current and speed up evenly. The starting controller has significant advantages in protection of motors, electrical devices, power grid and conservation of energy. The controller’s design is elaborate in terms of starting, stopping, protecting against failure, communicating, alarming and displayer. In comparison with obsolete starters, it boast itself of such characteristics, as high level of automation, less starting current (usually being less than 1.3 times of rated current), less electrical and mechanical shock, and it is especially suitable for starting under heavy load. Even in the event that power grid voltage is low, it can start successfully. It reduces capacity of transformer. At present it is a most desirable starting controller for ball mill, hoister, crusher, compressor, fan and water pump under heavy load.

 

二、性能特點

II. Performance and features

1、、性能遠優于頻敏變阻器、油浸變阻器、鑄鐵電阻等起動器。

It is superior to frequency sensitive rheostat, oil immersing rheostat and cast iron rheostat in terms of performance.

2、起動電流小,小于電機額定電流的1.3倍。

Its starting current is less, which is less than 1.3 times of rated current of motors.

3、可連續起動5次。

It can start for 5 times in succession.

4、平滑起動:對設備無機械應力沖擊,可延長機械設備及電機的壽命。

Its starting process is smooth: It has no shock of mechanical stress on devices, thus life of machineries and motors are prolonged.

5、可低壓起動:6千伏電機5.5千伏、380伏電機340伏可順利起動。

It can start under low voltage. It can start successfully in 5.5 KV for motors of 6 KV and in 340 V for motors of 380 V.

6、結構簡單、可靠,全部操作自動化,安裝、維護方便。

It is simple and reliable in structure. All operations are in automation. It is easy in installation and maintenance.  

分享到:

上一篇: 水阻柜電解粉能用什么替代?電解粉什么成份?電解粉怎么配比?電解粉阻值計算

下一篇: 球磨機靜止式進相器提高功率因數0.92以上

襄陽忠東機電設備有限公司 .鄂ICP備12015598號 . ?2014-2018 XYZDJD CHINA ALL RIGHTS RESERVED 站長統計

鄂公網安備 42060602000181號

山西11选五开奖走势表